318ti.org forum

Go Back   318ti.org forum > Technical, Maintenance and Modifications > Engine

Notices

Engine Tuneups, chips, wires, spark plugs.

.
» Recent Threads
1996 318ti M green, auto
05-06-2021 08:23 PM
Last post by FunElan
05-07-2021 08:23 PM
1 Replies, 1,563 Views
new to me 98 318ti
05-03-2021 04:16 PM
Last post by 1996 328ti
05-06-2021 12:47 AM
1 Replies, 1,288 Views
Crank timing
05-06-2021 12:19 AM
Last post by jmwilliams
05-06-2021 12:19 AM
0 Replies, 708 Views
1997 Black 318ti 5spd...
03-28-2021 09:11 PM
Last post by AustinTX
05-05-2021 03:41 PM
7 Replies, 2,964 Views
318 Track Day VIR
04-29-2021 04:30 AM
Last post by joe1602
05-05-2021 12:24 PM
1 Replies, 1,731 Views
Reply Share/Bookmark
 
Thread Tools Display Modes
Old 09-21-2016, 12:16 PM   #1
case of yuengling
Junior Member
 
case of yuengling's Avatar
 
Join Date: Sep 2016
Location: Athens, GA
Posts: 12
iTrader: (0)
Default New 318ti owner... fuel pump question

Hello all,

I have just picked up my first e36, a 1996 318TI sport. I got a great deal on the car but it is in need of a LOT of work.

Right now, there is a VERY strong odor of fuel inside the car. The previous owner claimed that a new fuel pump was recently installed. I removed the back seat and checked under both covers to try and locate a leak and found a bit of old, bad gas sitting in the top of the fuel pump housing. I looked all over and couldn't find a fuel leak and even drove the car around with the back seat out to see if I could see anything coming out, but there isn't.

I did quite a bit of reading here and elsewhere about the fuel pump setup on this car and from what I can tell, I do not think I have the correct fuel pump in the car. This pump is blue and only has one hose going to it. From what I read, this car should have a green pump, right?

First I need to know if I even have the correct fuel pump. As for the fuel smell, I'm assuming the o-ring is missing between the large cap that holds the pump in and the tank.

Here's a pic of what I'm dealing with, after I cleaned the old fuel gunk up:
case of yuengling is offline   Reply With Quote
Old 09-21-2016, 04:07 PM   #2
bazar01
Senior Member
 
bazar01's Avatar
 
Join Date: Aug 2009
Location: Georgia
Posts: 595
iTrader: (0)
Default

I remember there is only one hose connected to the fuel pump. That is the supply line or the pressure line located on the right hand side fuel tank where the fuel pump is.
The return line goes to the left hand side fuel tank.

As far as the fuel smell, make sure there is a rubber seal around the metal ring or it could be around the fuel pump flange.

The color does not matter. My original pump was blue and the replacement I bought was green.
__________________
1996 Ti 280k miles and still going....
1993 964 - holding on to this one
2001 Burban, 240k miles
2018 Suburban Z71
bazar01 is offline   Reply With Quote
Old 09-21-2016, 06:00 PM   #3
bluoval6
Member
 
Join Date: Oct 2015
Location: Slidell, Louisiana USA
Posts: 89
iTrader: (0)
Default

I had a similar problem with my 98. Every time I filled the tank, I would get a fuel odor for about 2 days. Ended up being a tiny crack in the driver's side housing (whatever that is on the driver's side in place of a pump). A little JB weld took care of it. Hope this helps.
bluoval6 is offline   Reply With Quote
Old 09-26-2016, 01:26 PM   #4
case of yuengling
Junior Member
 
case of yuengling's Avatar
 
Join Date: Sep 2016
Location: Athens, GA
Posts: 12
iTrader: (0)
Default

Thanks for the feedback, guys. I pulled the fuel pump out and realized whoever put the fuel pump in didn't put the seal on right. It was halfway on the pump and halfway hanging down in the tank.

I also found that the fuel gauge sender wiring and a vent hose has been chewed up by a rat at some point. Awesome.
case of yuengling is offline   Reply With Quote
Reply

Bookmarks


Currently Active Users Viewing This Thread: 1 (0 members and 1 guests)
 
Thread Tools
Display Modes

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off

Forum Jump

Similar Threads
Thread Thread Starter Forum Replies Last Post
Fuel Pump Relay!!!!! Grizzly Electrical 14 10-06-2020 07:56 PM
How the FUEL pump relay gets signal from DME?? goyal99 Engine 12 04-06-2020 03:21 PM
Fuel pump assembly question ChicksLikeLifts Misc 0 09-13-2013 02:20 AM
fuel pump noise question marleymon Misc 0 06-09-2013 04:32 AM
Possibly stupid question (fuel pump relay) D33p Electrical 12 02-14-2008 04:03 PM


All times are GMT +1. The time now is 04:41 AM.


.
Powered by site supporters
vBulletin Version 3.8.8
Copyright ©2000 - 2021, Jelsoft Enterprises Ltd.
Copyright ©1999 - 2021, 318ti.org
© vBadvanced CMPS v3.2.2
[page compression: 71.04 k/82.63 k (14.02%)]

318ti.org does not warrant or assume any legal liability or responsibility for the accuracy, completeness, or usefulness of any information or products discussed.